This work reports the fabrication and comprehensive characterization of \(\mathrm{Bi_{2-x}Pb_xSr_2Ca_2Cu_3O_{10+\gamma}}\) superconducting tapes with coexistence of Pb-doped Bi-2223 and Bi-2212 phases, embedded in a high-purity silver matrix. The tapes were produced by the powder-in-tube (PIT) method, followed by heat treatments at 865 and 810 °C and mechanical lamination, yielding homogeneous tapes with a thickness of about 0.6 mm. Structural analysis by X-ray diffraction shows that the precursor powder consists mainly of the BPSCCO-2223 phase and a carbonate secondary phase, whereas the tape core additionally contains the BPSCCO-2212 phase, \(\mathrm{Ca_2PbO_4}\) and \(\mathrm{Ca_{2.675}Cu_3Pb_{0.535}Sr_{2.675}Bi_{1.6}O_x}\). SEM-EDS confirms the flattening and alignment of grains after rolling, the presence of Ca- and Pb-rich secondary phases, and the absence of detectable silver diffusion into the core. DC susceptibility measurements under 50 and 1000 Oe reveal two superconducting transitions in the core, associated with the 2223 and 2212 phases, and a clear reduction of the irreversibility temperature with respect to the powder. From hysteresis loops, the critical fields (\({H_{C1}}\) and \({H_{irr}}\)) and the vortex-matter \(B-T\) phase diagrams were constructed, showing a shift of the irreversibility line to lower fields and temperatures for the tape core. The critical current density estimated with the Bean model reaches values of the order of \(\mathrm{10^5\ A/cm^2}\) at 10 K for the tape core, with the enhancement attributed to grain alignment and secondary-phase pinning. Magnetic relaxation measurements show a complex, two-plateau decay in the core at 5 K, attributed to the competition between the coexisting 2223 and 2212 phases. The results provide a complete picture of the microstructural, magnetic and transport behaviour of Pb-doped Bi-2223 tapes and establish a basis for their optimisation.
- Open Access
- Article
Fabrication and Characterization of High-Temperature Superconducting \(\mathbf{Bi_{2-x}Pb_xSr_2Ca_2Cu_3O_{10+\gamma}}\) Tapes
- Diego André Orna Tiburcio 1,2,
- Henry E. Sanchez Cornejo 1,*,
- Jorge García Dulanto 1,
- Melvin James Godoy 1,
- Angel G. Bustamante Domínguez 1,
- Jesus Flores Santibañez 1,
- Juan Carlos González 1,
- Santos Ricardo Celis Rojas 3,
- Crispin H. W. Barnes 4 and
- Luis De Los Santos Valladares 4,5,6,*
Author Information
Received: 24 May 2026 | Revised: 24 September 2026 | Accepted: 19 October 2026 | Published: 03 November 2026
Abstract
Graphical Abstract
References
- 1.
Bednorz, J.G.; Müller, K.A. Possible High Tc Superconductivity in the Ba−La−Cu−O System. Z. Phys. B-Condens. Matter 1986, 64, 189–193. https://doi.org/10.1007/bf01303701.
- 2.
Maeda, H.; Tanaka, Y.; Fukutomi, M.; et al. A New High-TC Oxide Superconductor without a Rare Earth Element. Jpn. J. Appl. Phys. 1988, 27, L209. https://doi.org/10.1143/jjap.27.l209.
- 3.
Shimoyama, J.I.; Motoki, T. Current Status of High Temperature Superconducting Materials and Their Various Applications. IEEJ Trans. Electr. Electron. Eng. 2024, 19, 292–304. https://doi.org/10.1002/tee.23976.
- 4.
Hayashi, K. Commercialization of Bi-2223 Superconducting Wires and Their Applications. SEI Tech. Rev. 2020, 91, 68–74.
- 5.
Kametani, F.; Jiang, J.; Matras, M.; et al. Comparison of Growth Texture in Round Bi2212 and Flat Bi2223 Wires and Its Relation to High Critical Current Density Development. Sci. Rep. 2015, 5, 8285. https://doi.org/10.1038/srep08285.
- 6.
Xia, S.K.; Lisboa, M.B.; Serra, E.T.; et al. Bi-2223/Ag Tapes Prepared at Temperatures above the Bi-2223 Decomposition Temperature. Supercond. Sci. Technol. 2001, 14, 103–108. https://doi.org/10.1088/0953-2048/14/2/308.
- 7.
Pu, M.H.; Song, W.H.; Zhao, B.; et al. Enhanced Flux Pinning in (Bi, Pb)-2223/Ag Tapes by Slightly over-Doped Pb. Supercond. Sci. Technol. 2001, 14, 299–304. https://doi.org/10.1088/0953-2048/14/6/301.
- 8.
Vadakkaathillam, G.; Sathyanarayana, A.T.; Amaladass, E.P.; et al. Evolution of Superconducting Properties of Coexistent Bi-2212 and Bi-2223 Phases in BSCCO. Indian J. Pure Appl. Phys. 2021, 59, 391–397. https://doi.org/10.56042/ijpap.v59i5.39831.
- 9.
Ali, M.A.; Banerjee, S.S. Coexistence of Different Pinning Mechanisms in Bi-2223 Superconductor and Its Implications for Using the Material for High Current Applications. J. Appl. Phys. 2022, 131, 243901. https://doi.org/10.1063/5.0093741.
- 10.
Mawatari, Y.; Yamasaki, H.; Kosaka, S.; et al. Critical Current Properties and Vortex-Glass-Liquid Transition in Ag-Sheathed Bi-2223 Tapes. Cryogenics 1995, 35, 161–167. https://doi.org/10.1016/0011-2275(95)93989-d.
- 11.
Zhang, S.; Ma, X.; Shao, B.; et al. Fabrication of Multifilamentary Powder in Tube Superconducting Tapes of Bi-2223 with Sr Deficient Starting Composition. Cryogenics 2021, 114, 103245. https://doi.org/10.1016/j.cryogenics.2020.103245.
- 12.
Wimbush, S.C.; Strickland, N.M.; Long, N.J. Low-Temperature Scaling of the Critical Current in 1 G HTS Wires. IEEE Trans. Appl. Supercond. 2015, 25, 1–5. https://doi.org/10.1109/tasc.2014.2362726.
- 13.
Kodama, T.; Fukuda, M.; Shiraishi, K.; et al. E–J Characteristics in a Wide Range of Electric Field for a Bi-2223 Silver-Sheathed Tape Wire. Phys. C Supercond. 2001, 357–360, 582–585. https://doi.org/10.1016/s0921-4534(01)00314-8.
- 14.
Obradors, X.; Puig, T.; Ricart, S.; et al. Progress in Superconducting REBa2Cu3O7 (RE = Rare Earth) Coated Conductors Derived from Fluorinated Solutions. Supercond. Sci. Technol. 2024, 37, 053001. https://doi.org/10.1088/1361-6668/ad36eb.
- 15.
Takeda, Y.; Motoki, T.; Kitaguchi, H.; et al. High IC Superconducting Joint between Bi2223 Tapes. Appl. Phys. Express 2019, 12, 023003. https://doi.org/10.7567/1882-0786/aaf8b4.
- 16.
Cornejo, H.S.; De Los Santos Valladares, L.; Kamboj, V.S.; et al. Texture and Terahertz Analysis of YBa2Cu3O7 Grown onto LaAlO3 by the Chemical Solution Deposition Technique. Heat Treat. Surf. Eng. 2022, 3, 1–8. https://doi.org/10.1080/25787616.2021.2022294.
- 17.
Domínguez, A.B.; De Los Santos Valladares, L.; Cornejo, H.S.; et al. YBa2Cu3O7 Films Grown onto SrTiO3 and YSZ Substrates by Chemical Solution Deposition of Trifluoroacetates. J. Electroceramics 2021, 47, 15–22. https://doi.org/10.1007/s10832-021-00256-5.
- 18.
Bustamante Dominguez, A.G.; Sanchez Cornejo, H.E.; González, J.C.; et al. Aging and Environmental Effects on the Superconductor [Y1−xCax]SrBaCu2.80(BO3)0.20Oy with 0.10 ≤ x ≤ 0.50. J. Supercond. Nov. Magn. 2024, 37, 1903–1911. https://doi.org/10.1007/s10948-024-06745-2.
- 19.
Cornejo, H.S.; De Los Santos Valladares, L.; Barnes, C.H.W.; et al. Texture and Magnetic Anisotropy of YBa2Cu3O7-X Film on MgO Substrate. J. Mater. Sci. Mater. Electron. 2020, 31, 21108–21117. https://doi.org/10.1007/s10854-020-04623-w.
- 20.
Krabbes, G.; Fuchs, G.; Canders, W.R.; et al. High Temperature Superconductor Bulk Materials; Wiley: Weinheim, Germany, 2006. https://doi.org/10.1002/3527608044.
- 21.
Cornejo, H.S.; Domínguez, A.B.; Holmes, S.N.; et al. Vortex Dynamics Study on an Uniaxially Textured YBCO/MgO Superconducting Film from Magnetic Measurements. Supercond. Sci. Technol. 2025, 38, 035028. https://doi.org/10.1088/1361-6668/adb6d8.
- 22.
Bean, C.P. Magnetization of High-Field Superconductors. Rev. Mod. Phys. 1964, 36, 31–39. https://doi.org/10.1103/revmodphys.36.31.
- 23.
Huang, Y.B. Progress in Bi-2223 Tape Performance. AIP Conf. Proc. 2002, 614, 717–723. https://doi.org/10.1063/1.1472607.
- 24.
Ye, C.L.; Li, M.Y.; Chen, X.P.; et al. Microstructure and Critical Current of Bimetallic Sheathed Bi-2223 Tapes. Phys. C Supercond. Its Appl. 2011, 471, 1107–1109. https://doi.org/10.1016/j.physc.2011.05.136.
- 25.
López, M.; Mariño, A. Fabricación Y Caracterización De Cintas Superconductoras De Alta Temperatura Crítica. MOMENTO 2006, 25–33.
- 26.
Hayashi, K.; Hikata, T.; Kaneko, T.; et al. Development of Ag-Sheathed Bi-2223 Superconducting Wires and Their Applications. IEEE Trans. Appl. Supercond. 2001, 11, 3281–3284. https://doi.org/10.1109/77.919763.
- 27.
Fischer, K.; Schubert, M.; Rodig, C.; et al. Processing, Microstructure and Critical Current Density of 2223 BPSCCO/Ag Tapes. IEEE Trans. Appl. Supercond. 1995, 5, 1259–1262. https://doi.org/10.1109/77.402790.
- 28.
Cornejo, H.S.; Domínguez, A.B.; Holmes, S.N.; et al. Reply to Comment on ‘Vortex Dynamics Study on an Uniaxially Textured YBCO/MgO Superconducting Film from Magnetic Measurements’. Supercond. Sci. Technol. 2026, 39, 088001. https://doi.org/10.1088/1361-6668/ae97be.
This work is licensed under a Creative Commons Attribution 4.0 International License.
